Max deduction for A/C that does not blow cold? - ZR-1 Net Registry Forums

bowtiguy · 08-09-2019

Any experts know what I can expect for a deduction total on the A/C that doesn't drop the recommended 20 degrees? I trusted my A/C guy a little too much and I don't have the time to address it prior to judging next weekend.

Little background on the car. Under 10K miles. all parts are factory installed. the only condition issue is a slightly rubbed aluminum crimp near the coolant crossover pipe. Blower motor, control center , all vents, heat work just fine.

lfalzarano · 08-09-2019

Take it in for the AC now. It’s only going to get hotter!

Sent from my iPhone using ZR-1 Net Registry

bowtiguy · 08-09-2019

Quote:

Originally Posted by lfalzarano

Take it in for the AC now. It’s only going to get hotter!

Sent from my iPhone using ZR-1 Net Registry

It will be fixed, but I'm not letting some ham fisted tech pull my plenum to get to the compressor after a full restoration. I'll weigh my options... stay with R12 or go to R134. I've got bent windows in the 68' C10 and good air in my H3 Alpha for now!

lfalzarano · 08-09-2019

Have them change it out to R134a. There are no hoses, switches or compressor to change out.

My was fixed a few weeks ago. It was a clutch switch that had gone bad. The R134a cools just fine.

Sent from my iPhone using ZR-1 Net Registry

DRM500RUBYZR-1 · 08-09-2019

Flight Judging or Performance Verification?

PV = Fail

Flight Judging = 25 points ( if they catch it )

Marty

bowtiguy · 08-10-2019

Quote:

Originally Posted by lfalzarano

Have them change it out to R134a. There are no hoses, switches or compressor to change out.

My was fixed a few weeks ago. It was a clutch switch that had gone bad. The R134a cools just fine.

Sent from my iPhone using ZR-1 Net Registry

I WISH it was that easy on my car. wont hold a vac test. spent 98% of its life in dry Colorado so I suspect seals -everywhere.

Quote:

Originally Posted by DRM500RUBYZR-1

Flight Judging or Performance Verification?

PV = Fail

Flight Judging = 25 points ( if they catch it )

Marty

Flight Judging. 25 points is minimal in the overall picture. The repair is not doable before I leave on the 16th. Maybe I'll get the flight judging completed first, install new parts..then go for the PV.

R12 compressor runs when jumped at the switch. A forum member recommended rebuilding it while my plenum was off over the winter, but we just suspected bad schrader valves. The R12 compressor rebuild kits are cheap and would allow me to keep all the date coded factory parts VS. putting 94-95 parts in and making it functional. that is "IF" the factory line crimps are still holding....my oil cooler lines sure didnt.

Even though you cant read the part number/ date code of a 91 compressor ( its on the bottom) How much of a points deduction comes with putting 94-95 134a parts into a 91 car?

WHY am I going down this rabbit hole! I should have put my Port and polished top end form my other motor on the car over the winter along with my factory A-molds, period correct modified Borla exhaust & short shifter and been driving it all summer!!!

lfalzarano · 08-10-2019

The 94-95 AC parts are metric and 90-93 are US customary measures.

Sent from my iPhone using ZR-1 Net Registry

Joelbbvette · 08-10-2019

Flight judging is 25 points for operations but they only feel for cold. Since the system is tested with fan speeds, Defrost, heat, etc. you should not see a total fail anyway. Again for PV, don't bother it is a total failure. Good luck with your flight judging and you should do fine. Let us know how it ends up.

bowtiguy · 08-10-2019

Quote:

Originally Posted by lfalzarano

The 94-95 AC parts are metric and 90-93 are US customary measures.

Sent from my iPhone using ZR-1 Net Registry

I gathered that from subfixer's thread...

http://www.zr1.net/forum/showthread.php?t=30748

At this point it would be an "all in" proposition with everything being never 134 components if I couldnt get the system to hold a vac after rebuilding the R12 compressor and installing new gaskets/o-rings everywhere. I tend to through more $$$ at repairs and fix everything at once.

Quote:

Originally Posted by Joelbbvette

Flight judging is 25 points for operations but they only feel for cold. Since the system is tested with fan speeds, Defrost, heat, etc. you should not see a total fail anyway. Again for PV, don't bother it is a total failure. Good luck with your flight judging and you should do fine. Let us know how it ends up.

thanks, pretty clear it has to be 100% to pass the performance verification. More importantly, it gets HOT here and with all the californians and texans moving to Colorado, A/C is a must for happy cruising in traffic ...even in a "dry" heat.

dredgeguy · 08-12-2019

Quote:

Originally Posted by lfalzarano

Have them change it out to R134a. There are no hoses, switches or compressor to change out.

My was fixed a few weeks ago. It was a clutch switch that had gone bad. The R134a cools just fine.

Sent from my iPhone using ZR-1 Net Registry

My clutch switch is acting up. Purchased a new one off ebay but not correct. Where did you get yours?
Thanks

08-09-2019	#1
bowtiguy Join Date: Aug 2005 Location: Cali-rodo Posts: 270	Max deduction for A/C that does not blowing cold? Any experts know what I can expect for a deduction total on the A/C that doesn't drop the recommended 20 degrees? I trusted my A/C guy a little too much and I don't have the time to address it prior to judging next weekend. Little background on the car. Under 10K miles. all parts are factory installed. the only condition issue is a slightly rubbed aluminum crimp near the coolant crossover pipe. Blower motor, control center , all vents, heat work just fine. Last edited by bowtiguy; 08-10-2019 at 10:03 AM.

08-09-2019	#2
lfalzarano Join Date: Feb 2011 Location: Clayton, North Carolina Posts: 1,133	Re: Max deduction for A/C that does not blow cold? Take it in for the AC now. It’s only going to get hotter! Sent from my iPhone using ZR-1 Net Registry __________________ Lou[COLOR="Red"][B][SIZE="4"][/SIZE][/B][/COLOR]

08-09-2019	#4
lfalzarano Join Date: Feb 2011 Location: Clayton, North Carolina Posts: 1,133	Re: Max deduction for A/C that does not blow cold? Have them change it out to R134a. There are no hoses, switches or compressor to change out. My was fixed a few weeks ago. It was a clutch switch that had gone bad. The R134a cools just fine. Sent from my iPhone using ZR-1 Net Registry __________________ Lou[COLOR="Red"][B][SIZE="4"][/SIZE][/B][/COLOR]

08-09-2019	#5
DRM500RUBYZR-1 Join Date: Sep 2008 Location: Mullica Hill, New Jersey Posts: 2,592	Re: Max deduction for A/C that does not blow cold? Flight Judging or Performance Verification? PV = Fail Flight Judging = 25 points ( if they catch it ) Marty

08-10-2019	#7
lfalzarano Join Date: Feb 2011 Location: Clayton, North Carolina Posts: 1,133	Re: Max deduction for A/C that does not blowing cold? The 94-95 AC parts are metric and 90-93 are US customary measures. Sent from my iPhone using ZR-1 Net Registry __________________ Lou[COLOR="Red"][B][SIZE="4"][/SIZE][/B][/COLOR]

08-10-2019	#8
Joelbbvette Join Date: Oct 2017 Location: Tampa, FL / Rockledge, FL Posts: 194	Re: Max deduction for A/C that does not blow cold? Flight judging is 25 points for operations but they only feel for cold. Since the system is tested with fan speeds, Defrost, heat, etc. you should not see a total fail anyway. Again for PV, don't bother it is a total failure. Good luck with your flight judging and you should do fine. Let us know how it ends up. __________________ Joel Tampa/Rockledge, FL Present Collection 1969 350/300 AC Convertible 1972 454 Coupe 2nd Owner 1988 KOH EX5006 - ZR-1 Prototype 1990 ZR-1 #277 NCRS Dave McLellan Award 2019 1994 Copper Convertible NCRS Dave Hill Award 2012 2001 Z06 122k miles