Alternator or Battery??? - ZR-1 Net Registry Forums

-=Jeff=- · 09-30-2009

how do you know which it is?

I know my battery is about 5 years old and is an Optima red top, I always keep it on a Battery tender..

I am thinking the Alternator might be going

Also it looks like the LT1/4 Alternator which is a 140A will work in place of the 124A.. I did that on my 89, I think that might be a good route to go..

any thoughts??

Dynomite · 10-01-2009

If you have NO DEAD cells in the battery and your alternator is putting out 13.5 - 14.5 volts when engine is running (just put a volt meter on battery terminals) it seems neither is an issue, however, a battery as it ages will have less capability to hold a charge so I would say time for new battery.

You might just set battery on shelf and see if it looses charge or it only looses charge when installed. The latter case may be some kind of excessive power drain in electrical system with switch off. 124 amp should be good enough unless you have added electrical components drawing high amperage which I can offer no excuse for my 200 amp alternator.

-=Jeff=- · 10-01-2009

Quote:

Originally Posted by Dynomite

If you have NO DEAD cells in the battery and your alternator is putting out 13.5 - 14.5 volts when engine is running (just put a volt meter on battery terminals) it seems neither is an issue, however, a battery as it ages will have less capability to hold a charge so I would say time for new battery. You might just set battery on shelf and see if it looses charge or it only looses charge when installed. The latter case may be some kind of excessive power drain in electrical system with switch off.

Car idling, with lights on: 13.0v at Battery using DMM

I did notice the Voltmeter in the car fluctuates more, usually sits about mid way most of the time, but sometimes lately at idle it drops lower

I will probably swap the Alt first, then the battery, unless there is a definitive test I could run without taking the battery in to test it

EDIT: I should also add, the light do dim at idle, quite noticeable too

Dynomite · 10-01-2009

Seems to me that if you have 13 volts at idle with lights on and prolly 13.5 - 14.5 volts at higher rpms with lights off.....I would say battery.

But you did not say what your symptoms were...I assume your battery goes dead overnight or some such but that is not possible being on a tender unless it just is not charging up...have you tested each cell with a specific gravity tester? And then with battery on bench testing specific gravity in each cell to make sure it holds a charge over night with tender not connected? Each cell of a charged battery should float 4 of those little colored balls in the specific gravity tester.

My experience with alternators is that they go FAST....loosing all output at once and not loosing a bit of voltage output over time. A battery on the other hand can get bad S L O W E L Y.

-=Jeff=- · 10-01-2009

Quote:

Originally Posted by Dynomite

Seems to me that if you have 13 volts at idle with lights on and prolly 13.5 - 14.5 volts at higher rpms with lights off.....I would say battery.

But you did not say what your symptoms were...I assume your battery goes dead overnight or some such but that is not possible being on a tender unless it just is not charging up...have you tested each cell with a specific gravity tester? And then with battery on bench testing specific gravity in each cell to make sure it holds a charge over night with tender not connected? Each cell of a charged battery should float 4 of those little colored balls in the specific gravity tester.

My experience with alternators is that they go FAST....loosing all output at once and not loosing a bit of voltage output over time. A battery on the other hand can get bad S L O W E L Y.

just noticed the voltage on the gauge int he car is reading lower then normal at times.. I might just get the battery tested. no other real sypmtom other the odd ( lower) readings on the OEM gauge

You might be right as the battery is 5 years old now

GOLDCYLON · 10-01-2009

Drive the car to Autozone and have them load test the battery. You will find out quick Jeff if its an internal short.

Dynomite · 10-01-2009

Quote:

Originally Posted by -=Jeff=-

just noticed the voltage on the gauge int he car is reading lower then normal at times.. I might just get the battery tested. no other real sypmtom other the odd ( lower) readings on the OEM gauge

You might be right as the battery is 5 years old now

I am not sure if you have a sealed (no maintenance) battery...but you can get the little specific gravity tester at any local auto parts store for a couple bucks. Or WallyMart will be happy to test the battery for you.

Have the battery tested after it has been tended on a bench to eliminate the possibility of an electrical issue in your ZR1 with ignition switch off if you are testing by specific gravity. You may think you are tending the battery installed but it is draining as fast as you are tending.

-=Jeff=- · 10-01-2009

Quote:

Originally Posted by Dynomite

I am not sure if you have a sealed (no maintenance) battery...but you can get the little specific gravity tester at any local auto parts store for a couple bucks. Or WallyMart will be happy to test the battery for you.

Have the battery tested after it has been tended on a bench to eliminate the possibility of an electrical issue in your ZR1 with ignition switch off if you are testing by specific gravity. You may think you are tending the battery installed but it is draining as fast as you are tending.

right but every other car I have had with a no maintenance battery like clock work.. 4.5 to 5 years.. battery is done

I doubt it is an internal issue on my Z.. I just noticed it, but I have not driven the car in a couple weeks either. Again, I do know my Optima is 5 years old might even be 6 years. I will get it tested and go from there. When I was working on the windows this past couple months I drained the battery once or twice ( not to dead) but down to maybe 9-10 volts ( guessing)

only thing I noticed was the OEM gauge reading

GOLDCYLON · 10-01-2009

Quote:

Originally Posted by Dynomite

I am not sure if you have a sealed (no maintenance) battery...but you can get the little specific gravity tester at any local auto parts store for a couple bucks. Or WallyMart will be happy to test the battery for you.

Have the battery tested after it has been tended on a bench to eliminate the possibility of an electrical issue in your ZR1 with ignition switch off if you are testing by specific gravity. You may think you are tending the battery installed but it is draining as fast as you are tending.

Quote:

Originally Posted by -=Jeff=-

I know my battery is about 5 years old and is an Optima red top, I always keep it on a Battery tender..

Im pretty sure all the Optimas are sealed so he wont be able to go cell to cell to check the specific gravity

Dynomite · 10-01-2009

Quote:

Originally Posted by GOLDCYLON

Im pretty sure all the Optimas are sealed so he wont be able to go cell to cell to check the specific gravity

Your advice is BEST

Get a battery load test

09-30-2009	#1
-=Jeff=- Join Date: Jul 2007 Location: Bartlett, IL Posts: 7,169	Alternator or Battery??? how do you know which it is? I know my battery is about 5 years old and is an Optima red top, I always keep it on a Battery tender.. I am thinking the Alternator might be going Also it looks like the LT1/4 Alternator which is a 140A will work in place of the 124A.. I did that on my 89, I think that might be a good route to go.. any thoughts?? __________________ 1990 Corvette ZR-1 #1051 Watson Headers (2" Primary) - Flowmaster Cats - Borla Catback Late Model IH - Plenum Coilovers - 4.10s Custom Interior NCM Lifetime Member #978

10-01-2009	#2
Dynomite Join Date: Aug 2009 Location: South Dakota/California Posts: 3,797	Re: Alternator or Battery??? If you have NO DEAD cells in the battery and your alternator is putting out 13.5 - 14.5 volts when engine is running (just put a volt meter on battery terminals) it seems neither is an issue, however, a battery as it ages will have less capability to hold a charge so I would say time for new battery. You might just set battery on shelf and see if it looses charge or it only looses charge when installed. The latter case may be some kind of excessive power drain in electrical system with switch off. 124 amp should be good enough unless you have added electrical components drawing high amperage which I can offer no excuse for my 200 amp alternator. __________________ Left Clickable links -Solutions- LT5 Modifications/Rebuild Tricks Low Mileage ZR-1 Restoration 1990 Corvette (L98) Modifications LT5 Eliminated Systems LT5 Added Systems LT5/ZR-1 Fluids 1995 LT5 SPECIFIC TOP END REBUILD TRICKS Last edited by Dynomite; 10-01-2009 at 12:06 AM.

10-01-2009	#4
Dynomite Join Date: Aug 2009 Location: South Dakota/California Posts: 3,797	Re: Alternator or Battery??? Seems to me that if you have 13 volts at idle with lights on and prolly 13.5 - 14.5 volts at higher rpms with lights off.....I would say battery. But you did not say what your symptoms were...I assume your battery goes dead overnight or some such but that is not possible being on a tender unless it just is not charging up...have you tested each cell with a specific gravity tester? And then with battery on bench testing specific gravity in each cell to make sure it holds a charge over night with tender not connected? Each cell of a charged battery should float 4 of those little colored balls in the specific gravity tester. My experience with alternators is that they go FAST....loosing all output at once and not loosing a bit of voltage output over time. A battery on the other hand can get bad S L O W E L Y. __________________ Left Clickable links -Solutions- LT5 Modifications/Rebuild Tricks Low Mileage ZR-1 Restoration 1990 Corvette (L98) Modifications LT5 Eliminated Systems LT5 Added Systems LT5/ZR-1 Fluids 1995 LT5 SPECIFIC TOP END REBUILD TRICKS Last edited by Dynomite; 10-01-2009 at 12:33 AM.

10-01-2009	#6
GOLDCYLON Join Date: May 2007 Location: Peoria, AZ Posts: 9,155	Re: Alternator or Battery??? Drive the car to Autozone and have them load test the battery. You will find out quick Jeff if its an internal short. __________________ GOLDCYLON - 91 ZR-1 #2014 GOLDCYLON - 90 ZR-1 #2794, 4L60e (Formerly Schrade's) GOLDCYLON - 11 CTS-V Arizona State Director 91 WHITE/BLACK #2014. 380 P&P&PCed,Ported Heads, Jeal Long tubes, Corsa Exhaust/FIKSE FM-5s /LED TLs, LED Headlights, Front Wilwood 6 piston narrowlite calipers and rear Wilwood caliper street shop mod,CNCed Coolant Pipes,TPI Cvr,Filter cover,Stainless Bolts, DRM/DOM PROM /ZFDOC mod build #102,DRLs,BMAD with stainless Debris Screen,Coplan Air Blaster, Pioneer APP Radio 4,Brey-Krause HB,Sub Bar,Fire extinguisher seat mount,DRM Coilovers,LEDs everywhere,Compass mirror (orange),V1 DIC hidden display, Homelink sun visor, Carbon Fiber top x3 and APSIS Carbon Fiber interior, APSIS CF Steering Wheel/NAPA Leather, Banski trailing arms, Guldstrand front suspension,urethane bushings from Prothane (total suspension) ZFDoc drive shaft safety loop, raptor shift light (orange),AO engineering louver front plate, Console seat cushion, 96CE seats with black custom Sheepskins, ss billet catch can,Viper remote entry/alarm,Cragar Rear Louvers,LED side louver lights, Dewitts Radiator with SPAL fans and a Woods 160 T-Stat 90 RED/BLACK #2794. 4L60e Automatic Stage V by RPM Transmission, TCI Dedicated TCM, OBX Stainless Headers, Corsa Exhaust, SAN Secondaries and Haibeck PROM, Exotic Muscle Coil overs, LED Interior Lights, LED Tail Lights, LED Headlights, 94 Sport seats with black custom Sheepskins , Cragar rear louvers, GS Front calipers, Banski Trailing arms, APSIS Carbon Fiber steering wheel, Front and Rear Baer Eradispeeds, DRLs, Guldstrand front suspension,urethane bushings from Prothane (total suspension), Dewitt's Raditor with Dual SPAL fans and a Haibeck 170 T-Stat 11 RED/GREY CTS-V

Thread Tools
Show Printable Version Email this Page
Display Modes
Switch to Linear Mode Hybrid Mode Switch to Threaded Mode