ZR-1 Net Registry Forums  

Go Back   ZR-1 Net Registry Forums > C4 ZR-1 > C4 ZR-1 Technical Postings

 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 01-12-2013   #1
Gunny
 
Gunny's Avatar
 
Join Date: May 2005
Location: Georgia Mountains
Posts: 925
Question Bad Fuel Pump ???

Quick disclaimer ... I've already searched our forum & have read as much as possible on fuel pump issues, replacement, etc.

My situation:
90 ZR-1 w/128,000 miles. I have all the service records since 70K miles and the fuel pumps have not been serviced/replaced during that time so I'm assuming that I have the original pumps.

Symptoms:
started about 2 weeks ago after not being driven for a couple of months. Engine started normally, no indication of problems, but the engine began "bucking" and cutting out/missing at 3000 rpm as if it had no fuel. It did not seem to be an ignition problem. Service engine light came on briefly but went out almost immediately. The engine missing occurs above 3000 rpm whether under load or not. After driving for 10 minutes or so, the missing stopped and everything seems normal ... full power, etc. A/C plugs & Accel injectors are all quite new, with only trips to BG & Carlisle ... fuel filter also fairly recent. Except for trips outside of my immediate area the Z always gets premium with NO ethanol (I have local access to non ethanol premium).

Analysis:
checked for loose vac hoses but no problem there. Put fuel pressure gauge on the rail and I'm reading 38lbs when key is first turned on. With engine on I have about 38-39 lbs at idle and with slightly higher RPM I get about 41-42 lbs. With engine not running and key on, the fuel pressure starts at 38 lbs but with each cycle of the pump turning on the pressure drops until it's down in the low 20's. If I charge the fuel rail up with key on and get the 38 lbs and then turn key off, the system holds the 38 lbs for quite a while (i.e. takes some time for the pressure to leak down). This is why I'm suspecting a fuel pump issue ... shouldn't I have 50+ lbs of fuel pressure?

In my mind it appears that I need to replace the fuel pumps but have I missed anything? Here's where I need the gurus to chime in ... Pete? others? any/all help & advice will be appreciated.

If I do need fuel pumps what's the best approach?
Rock Auto Part #P240KC. (Performance Electric) - less than $30 each
complete OEM kit - $345 from Jerry's Gaskets.
Obviously, a pair of pumps for $60 is more attractive than any more-expensive options but I don't want to make a bad decision on this issue.

I read the thread on the Bosch replacement requiring minor modifications (good writeup, btw) but I think I would prefer to replace without cutting, modifying, etc. I've never changed the fuel pumps on a Z (never have seen it done either) but it looks fairly straight forward. Any advice and/or tips would certainly be helpful.

Thanks in advance ... hope to see a bunch of good replies so I can get the Z back on the road. Any harm in driving it before I make repairs/replacements? ... or should I leave it parked? I just drove it again this morning hoping the problem had disappeared on its own, but alas, the first few times I hit 3K on the tach the engine began to cut out ... but after about 10 minutes all the symptoms were gone and everything seemed normal.
__________________
George Jones
Founding Member #14
www.zrwon.com
Gunny is offline   Reply With Quote
 

Tags
fuel pump


Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -4. The time now is 07:06 PM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Copyright ZR-1 Net Registry 2020